논문명 |
함수상태가 다른 경량골재와 천연골재를 사용한 콘크리트의 특성 비교 / Properties Comparison of Concrete Using Lightweight Aggregate with Different Water Conditions and Natural Aggregate |
저자명 |
박조범(Cho-Bum Park) ; 김용혁(Yong-Hyok Kim) ; 전유빈(Yu-Bin Jun) ; 김재홍(Jae-Hong Kim) ; 류득현(Deug-Hyun Ryu) |
발행사 |
한국콘크리트학회 |
수록사항 |
한국콘크리트학회논문집, Vol.31 No.5 (2019-10) |
페이지 |
시작페이지(459) 총페이지(8) |
ISSN |
1229-5515 |
주제분류 |
재료 / 구조 |
주제어 |
경량골재; 경량골재 콘크리트; 프리웨팅; 함수상태; 기건 경량골재//lightweight aggregate; lightweight concrete; pre wetting; water content condition; air-dried lightweight aggregate |
요약1 |
콘크리트의 자중을 줄이기 위해서 사용하는 경량골재는 흡수율이 높고, 밀도가 낮아, 콘크리트용 골재로 사용할 경우 유동성이 감소하는 단점이 있어, 경량골재에 프리웨팅을 실시하지만, 골재 전체가 균일한 함수량을 갖기는 매우 어렵다. 본 연구에서는 프리웨팅을 실시하지 않은 기건 상태의 경량골재를 대상으로 콘크리트 실험을 하였고, 함수상태에 따른 특성을 분석하고자 절건 경량골재를 사용한 콘크리트와 천연골재를 사용한 콘크리트도 함께 비교하였다. 실험결과, 경량골재를 사용한 콘크리트는 배합수 흡수에 따라 천연골재 콘크리트보다 유동성 손실이 발생하였으며, 함수량이 없는 절건 경량골재 계열이 크게 나타났다. 경량골재가 배합수를 흡수함에 따라 전체적으로 w/b 감소 효과가 나타나, 압축강도는 천연골재 콘크리트보다 증가하였으나, 골재 자체의 탄성계수가 낮아 콘크리트의 탄성계수는 감소하였다. 따라서 경량골재의 수요증진을 위해서 프리웨팅을 실시하지 않고, 기건 상태로 사용하여도 콘크리트의 특성을 발현하는 것으로 판단된다. |
요약2 |
As the lightweight aggregate used to reduce the weight of concrete has a high absorption rate, low density, and reduced liquidity in the concrete, pre-wetting is performed on the lightweight aggregate, but it is very difficult to have a uniform moisture content. In this study, concrete was tested on an air dried (ad) lightweight aggregate without pre-wetting, and concrete using natural aggregate was compared with concrete using a crude lightweight aggregate to analyze its characteristics according to the moisture conditions. The results of the experiment show that absorption of combined water resulted in a more fluid loss than natural aggregate concrete, and that the series of oven dried (od) lightweight aggregates with no moisture content. Overall, the w/b reduction effect of lightweight aggregate absorption increased, and the compressive strength was higher than that of natural aggregate concrete, but the elastic modulus factor of the aggregate itself was also reduced. Therefore, it is deemed that the pre-wetting method performed to enhance the demand of lightweight aggregates and that it also used in air dried state. |
소장처 |
한국콘크리트학회 |